Product ID:7406060 PHOSPHORIC AC AUX STAB SOL4X1G
MSDS Date:12/22/1988
FSC:6810
NIIN:00F044550
MSDS Number: BYKMR

ASHLAND CHEMICAL CO DIV OF ASHLAND OIL INC

COLUMBUS, OH 43216-2219
US

Emergency Phone: 800-274-5263/614-889-3333

Info Phone: 614-889-3333/800-274-5263

Cage: 34897

WALLACE AND TIERNAN DIVISION PENNWALT CORP

BELLEVILLE, NJ 07109-3010 US

Telephone: 614-790-3333/800-274-5263

Cage: 79172

WATER

CAS: 7732-18-5

RTECS: ZC0110000

Fraction By Weight: 30-60%

PHOSPHORIC ACID

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: 54%

OSHA PEL 1 MG/CUM

ACGIH TLV: 1 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: BURNS. INHALATION: MIST CAN
CAUSE DAMAGE TO NASAL & RESPIRATORY PASSAGES. INGESTION: RESULTS IN
SEVERE DAMAGE TO MUCOUS MEMBRANES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS

First Aid:SKIN/EYES: IMMEDIATELY WASH W/WATER FOR 15 MINS. INGESTION:
DON'T INDUCE VOMITING. VOMITING WILL CAUSE FURTHER DAMAGE TO
THROAT. DILUTE BY GIVING WATER. GIVE MILK OF MAGNESIA. KEEP WARM,
QUIET. INGEST ION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
OBTAIN MEDICAL ATTENTION IN ALL CASES.

Extinguishing Media:WATER FOG
Fire Fighting Procedures:NEVER USE WELDING/CUTTING TORCH ON/NEAR DRUM
(EVEN EMPTY) PRODUCT CAN IGNITE EXPLOSIVELY. WEAR A SCBA W/FULL
FACEPIECE OPERATED IN POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:ACID REACTS W/MOST METALS TO RELEASE
HYDROGEN GAS WHICH CAN FORM EXPLOSIVE MIXTURES W/AIR.

Spill Release Procedures:SMALL: COVER CONTAMINATED SURFACE W/SODIUM
BICARBONATE/SODA ASH/SLAKED LIME MIXTURE (50-50). MIX & ADD WATER
IF NECESSARY TO FORM A SLURRY. SCOOP UP & WASH W/SODA ASH SOLUTION.
LARGE: (SEE SUPP)

Handling and Storage Precautions:CONTAINERS MAY BE HAZARDOUS WHEN
EMPTIED. EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES. NEVER ADD
WATER TO ACIDS. ALWAYS ADD ACIDS TO WATER.
Other Precautions:ADDITION TO WATER RELEASES HEAT WHICH CAN RESULT IN
VIOLENT BOILING & SPATTERING. ALWAYS ADD SLOWLY & IN SMALL AMOUNTS.
NEVER USE HOT WATER.

Respiratory Protection:A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IN
ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA REGULATIONS ALSO
PERMIT OTHER NIOSH/MSHA RESPIRATORS (NEGATIVE PRESSURE TYPE).
Ventilation:MECHANICAL (GENERAL/LOCAL EXHAUST) VENTILATION TO MAINTAIN
EXPOSURE BELOW TLVS.
Protective Gloves:NEOPRENE/NITRILE RUBBER
Eye Protection:CHEMICAL SPLASH GOGGLES & FACE SHIELD
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS, POLYVINYL
CHLORIDE, POLYETHYLENE GLOVES.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DISCARD SHOES SATURATED W/PRODUCT.
Supplemental Safety and Health
SPILLS CONT'D: PERSONS NOT WEARING PROTECTIVE EQUIPMENT SHOULD BE
EXCLUDED FROM AREA UNTIL CLEAN-UP IS COMPLETED. STOP AT SOURCE.
DIKE TO PREVENT SPREADING. PUMP TO SALVAGE TANK.

Boiling Pt:B.P. Text:298F
Vapor Pres:6
Vapor Density:3.4
Spec Gravity:1.7

Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, ALKALI METALS.
Hazardous Decomposition Products:PHOSPHOROUS COMPOUNDS, HYDROGEN GAS

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.